1974-76 Model Merc 1500

General Information:

• This model was painted all "Phantom Black."
• The serial number was on a plate riveted to the swivel bracket above and between the clamp screws.
• Serial numbers 3752620 thru 4121434 were 1974 models.
• Serial numbers 4121435 thru 4319879 were 1975 models.
• Serial numbers 4319880 thru 4602011 were 1976 models.
• Merc 1500EL (Long Shaft, Electric Starting with Alternator) models were produced and Merc 1500 ELPT (Long Shaft, Electric Starting with factory installed Power Trim) were also produced in these years.
• Merc 1500E (Short Shaft, Electric Starting with Alternator) models were produced in 1974 & 1975.

Some items we have available for this model:

• Parts List 90-63293
• Owners manual 90-85274
• Dealer service manual 90-68647 (1974 models)
• Dealer service manual 90-75512 (1975-76 models)
• Consumer service manual SEL1408
• Emergency Starter Rope 47341A11
• Electric Starter Motor 50-72467
• Aftermarket Electric Starter Motor 50-72467-1
• Starter Solenoid 25661T1 (1974 models)
• New! Starter Solenoid 89-853654A1 (1975-76 models)
• New! Internal Wiring Harness 84-69236A1
• External Wiring Harness 84-822253T20
• Ignition Switch 54211T
• Powerhead Gasket Set 27-85653A87
• Standard Piston Rings 39-78816
• Top Crankshaft Seal 26-41953
• Bottom Crankshaft Seal 2 of 26-41953
• Spark Plug L76V (6 per engine)
• Spark Plug Wires 84-63212A2 (6 per engine)
• Spark Plug Boots 85-63709A2 (6 per engine)
• Distributor Cap Boots 85-94589 (6 per engine)
• Timing Belt 20140
• Charging System Rectifier 78614A1 (1974 models)
• New! Charging System Rectifier 816770T (1975-76 models)
• Ignition Trigger 393-3736A79 or
• Remanufactured Ignition Trigger 393-3736A79R
• Ignition Switchbox 332-2986A21
• Ignition Coil 332-4895A5 (1974 models)
• Ignition Coil 332-4895T2 (1975-76 models)
• Coil Wire 84-821945A5 (1974 models)
• New! Coil Wire 84-821945A2 (1975-76 models)
• Distributor Cap 393-4841A2
• Rotor and Shaft 393-4312
• Carburetor Rebuild Kit 1395-5109-1 (3 per engine)
• Carburetor Float 1395-8673 (3 per engine)
• Fuel connector for remote fuel line to plug into engine 22831T3
• Fuel Pump Rebuild Kit 21-30430A 7
• Tilt Adjusting Pin 17-49930A1
• Connecting tube for tilt rests 47802
• Lower Unit Driveshaft Seal 1 of 26-94038 and 1 of 26-16977
• Lower Unit Prop Shaft Seal 26-76868 (2 required)
• Complete Lower Unit Resealing Kit (all seals, gaskets, & o rings) 26-55682A1
• Water Pump Gasket, upper 27-858524
• Water Pump Gasket, lower 27-85608-1
• Water Pump Impeller 47-89984T4
• Aftermarket Water Pump Impeller Kit (Impeller, Gaskets, Wear Plate, etc.) 47-89984K
• Mercury Water Pump Kit (housing, impeller, gaskets, wear plate, etc.) 46-96148A8
• Gear Lube 92-802844A 1
• Gear Lube Drain & Vent Screws with gaskets 2 of 10-79953T2 (Used as both drain & vent screw on 1974 & prior models) (1975-76 models use 10-79953T2 for vent screw & 22-67892A06 magnetic drain screw)
• New! Magnetic Drain Screw 22-67892A06 (1975-76 models)
• Prop Nut Tabwasher 14-816629
• Prop Nut & Tabwasher Kit 11-52707T1
• Trim Tab Anode 31640T4
• Phantom Black Paint 92-802878--1
• Many additional parts, please inquire!

  ---

  <<Previous Model        Back to model listing         Ordering Information        Next Model>>

This information has been provided as a courtesy by Bob Grubb and Grubb's Marine. It is intended for personal use only. Copying and distributing of this information for any other purpose is strictly forbidden without the prior written consent of the author.